The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Also the question is, what causes an electric golf cart to hesitate? If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.
Additionally, why does my golf cart speed up and slow down? Check Speed Magnet: When your speed magnet fails in your sensor, your cart is going to have a tough time keeping up its speed, and it likely not only slows down but even stops completely.
Similarly, where is the speed sensor located on a Club car golf cart? Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
In this regard, why does my golf cart jump when I accelerate? The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn’t distribute power properly, then the cart may jerk as it accelerates. Thankfully, replacing the battery should be a good enough fix to manage this problem without difficulty.
How do I know if my golf cart controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
How do I know if my golf cart solenoid is bad?
- The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.
- If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
How do you check electric problems on a golf cart?
Look for a small red button located near the main power supply. Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn’t, try removing the motor and testing it with a separate, fully charged battery.
How often should you check golf cart batteries?
One integral aspect of this maintenance is battery watering. Unless you have a sealed battery, you should check the water level of your battery at regular intervals, usually about once a month, to ensure it is within the recommended range.
How do I make my golf cart go faster?
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart’s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
Why is my golf cart losing power up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
What controls the speed of a golf cart?
Essentially, your golf cart’s speed controller sends its current and battery voltage to its motor. This process depends on your golf cart’s input device, which includes its throttle. That’s how your golf cart’s speed controller lets you operate its acceleration rate, as well as its deceleration rate.
How do you remove the speed limiter on a electric golf cart?
How do I test my club car speed controller?
How can I make my electric golf cart go faster without upgrading?
- Wash Your Cart Properly.
- Inspect the Batteries.
- Refill the Battery Water.
- Check the Gas Pedal and Linkage.
- Measure the Tire Pressure.
- Charge Up Your Battery Unit.
- Lighten Up Your Cart’s Weight.
