- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart‘s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
Moreover, how do you adjust the governor on a EZ Go golf cart? Basically, an electric speed governor can be controlled by a tiny metal rod that’s located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
Additionally, how do you remove the speed limiter on a EZ Go golf cart?
Similarly, how fast does an ezgo golf cart go? Electric Motors Looking at the specifications for EZ Go electric golf carts, you notice a cart with a 36-volt motor is capable of 12 to 14 mph top speed. In addition, you notice a cart that’s powered by a 48-volt motor can reach speeds just below 20 mph.
Also the question is, how do you put a speed chip in a EZ Go golf cart?
Low Battery Usually, the most common reason golf carts slow down is when they don’t get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.How do you adjust the throttle cable on a EZ Go golf cart?
How can I make my electric golf cart go faster without upgrading?
- Wash Your Cart Properly.
- Inspect the Batteries.
- Refill the Battery Water.
- Check the Gas Pedal and Linkage.
- Measure the Tire Pressure.
- Charge Up Your Battery Unit.
- Lighten Up Your Cart’s Weight.
How can I make my 36V club car faster?
- Remove any unnecessary additions, racks or parts on your golf cart.
- Power-wash your cart.
- Check the shaft under the ignition pedal.
- Put larger tires on the cart.
- Replace any old or worn-out parts that are causing the cart to move slower than it should.
How fast does a 36V golf cart go?
Standard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires – You can purchase larger tires.
How can I make my golf cart gas faster?
Increase the RPM An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.
Where is the speed sensor on a ezgo golf cart?
Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.
How do I speed up my EZ Go RXV golf cart?
Increasing the speed of your EZ Go golf cart can be done by reprograming your speed control at the dealer, upgrading your batteries, motor, or replacing your speed control. Upgrading these can increase your typical speed from 12 MPH to 19.5 mph or above depending on your modifications.
What is freedom mode on a ezgo golf cart?
The EZ-Go speed chip, sometimes also called a freedom chip, is compatible with golf carts that use an electric Power Drive System (PDS) and are model year 2000 or newer. The chip increases the cart’s maximum speed from 13.5 mph to 19 mph.
Why does my golf cart go slow up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart’s slow speed.
Why is my golf cart so slow with new batteries?
Perhaps the most common reason that a golf cart slows down is when it doesn’t have enough power output from your battery. Often, this occurs if the battery pack charge is too low and your cart is out of power. However, if your cart is fully charged and has no problems there, the voltage output may be to blame here.
What does a speed controller do on a golf cart?
A controller works like a dimmer switch for a light. It varies “power” by modulating voltage. By using a controller, it allows the user to vary the current to the motor thus adjusting the speed of the vehicle. A larger controller is capable of providing more current thus allowing the motor to produce more torque.
How fast can a golf cart go without a governor?
Consult with your golf cart manufacturer, but replacing your speed control can increase your speed to 20 mph or more, depending on your upgrade. A typical electric cart without an upgraded speed control tops out around 12 mph.
How do you turn off the governor on a EZ Go golf cart?
- Detach the cable from the carburetor. The cable is about the width of a straw.
- Follow the disconnected cable up to the governor.
- Disconnect the gas pedal cable from the governor and reroute it to the carburetor.
- Using your wrench, remove the bolt on the gas pedal shaft.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.
How do I speed up my 36v EZ Go?
- Add More Torque to Your Golf Cart.
- Upgrade Your Golf Cart’s Motor.
- Improve the High-Speed Controller of the Cart.
- Add Better Golf Cart Tires.
- Use a Higher Powered Golf Cart Battery.
- Watch the Weight in Your Golf Cart.
